Scholarly record
COMPARISON OF ROCKWOOL AND PEAT SUBSTRATES FOR THE HIDROPONIC PRODUCTION OF GREENHOUSE CUCUMBERS
Abstract
Soilless hydroponic cultivation of cucumbers (Cucumis sativus L.) has expanded rapidly during the last few decades. One of the key factors in achieving high productivity in industrial greenhouses is the choice of growing medium. Rockwool has become dominant, especially in Europe. However, in addition to energy consumption during production, landfilling of rockwool as a non-biodegradable material is expensive and poses an environmental risk. Therefore, there is increasing use of organic substrates in the soilless cultivation of cucumbers. Coconut coir is most widely preferred for long-cycle production. Nowadays, there is almost no data on the use of peat as a stand-alone substrate in commercial hydroponic cucumber production. Despite recent ecological considerations, peat is attractive to vegetable growers, especially in peat-producing countries as a local, cost-effective, high-quality, reusable resource. Previously, significant problems limiting the use of peat substrates were peat instability, which resulted in reduced air exchange to the roots. Based on new technologies, peat could return to the long-cycle hydroponic cultivation of vegetables. The aim of the study was to determine the suitability of fractioned sphagnum sod peat substrate as an alternative to rockwool for hydroponic production of greenhouse cucumbers in equal microclimate, irrigation and fertilization conditions. The parameters assessed included leaf nutrient status, chlorophyll content in SPAD values, and cucumber yield. Overall, substrates did not statistically influence the concentrations of nutrients in both young and old cucumber leaves. Regardless of the substrate type, leaf nutrient content corresponded to the sufficiency range for cucumbers. The only imbalance was the low K at the end of the growth cycle in both age leaves, regardless of substrates. A strong positive correlation was found between chlorophyll content in SPAD values and N, K, Ca, Mg, S, Mn and Zn concentration in young cucumber leaves. The comparative study showed that cucumber plants had a stable high yield and high fruit quality during the autumn/winter cultivation in both substrates. Within the growth cycle, specially developed peat substrate had fully maintained its stability. Therefore, the sod peat substrate can be successfully used for industrial hydroponic production of high-yielding cucumber varieties without changes in cultivation technology developed for rockwool.
Publication Impact Profile
Publication details
References15
Gruda N.S., Increasing sustainability of growing media constituents and stand-alone substrates in soilless culture systems, Agronomy, vol. 9, 298, pp 1-24, 2019.
Savvas D., Gruda N., Application of soilless culture technologies in the modern greenhouse industry - a review, European Journal of Horticultural Science, vol. 83, pp 280–293, 2018.
Barrett G.E., Alexander P.D., Robinson J.S., Bragg N.C., Achieving environmentally sustainable growing media for soilless plant cultivation systems – a review, Scientia Horticulturae, vol. 212, pp 220-234, 2016.
Carlile W.R., Cattivelo C., Zaccheo P., Organic growing media: constituents and properties, Vadose Zone Journal, vol. 14/issue 6, pp 1-13, 2015.
Good agricultural practices for greenhouse vegetable crops: principles for Mediterranean climate areas, FAO plant production and protection papers, vol. 217, 616 pp, 2013.
Schmilewski G., Growing media constituents used in the EU in 2013, Acta Horticulturae, vol. 1168, pp 85-92, 2017.
Microwave plasma atomic emission spectroscopy (MP-AES). Application eHandbook, Agilent Technologies, 163 pp, 2021.
Rinkis G., Ramane H., Kunicka T., Methods of soil and plant analysis, Zinatne, Latvia, 174 pp, 1987 (in Russian).
Voogt W., Sonneveld C., Plant nutrition of greenhouse crops, Springer Dordrecht Heidelberg London New York, 431 pp, 2009.
Hochmuth G.J., Fertilizer management for greenhouse vegetables - Florida greenhouse vegetable production handbook, vol. 3, UF/IFAS Extension HS787, 19 pp, 2018.
Haifa. Nutritional recommendations for cucumber in open fields, tunnels and greenhouse, pp 76, https://www.haifa-group.com/sites/default/files/guide/Cucumber.pdf
Padilla F.M., Peña-Fleitas M.T., Gallardo M., Giménez C., Thompson R.B., Derivation of sufficiency values of a chlorophyll meter to estimate cucumber nitrogen status and yield, Computers and Electronics in Agriculture, vol. 141, pp 54-64, 2017.
Güler S., Ibrikci H., Büyük G., Effects of different nitrogen rates on yield and leaf nutrient contents of drip-fertigated and greenhouse-grown cucumber. Asian Journal of Plant Sciences, vol. 5, pp 657-662, 2006.
Kowalczyk K., Gajc-Wolska J., Mirgos M., Geszprych A., Kowalczyk., W., Sieczko L., Niedzinska M., Gajewski M., Mineral nutrients needs of cucumber and its yield in protected winter cultivation, with HPS and LED supplementary lighting. Scientia Horticulturae, vol. 265, 109217, pp 1-8, 2020.
Greenhouse cucumber production, New South Wales Department of Planning, Industry and Environment, Australia, 224 pp, 2019.
View or Download full articleAccess options
SWS access login
Login as SWS Scientific CommitteeLogin as SWS Scientific PartnerLogin as SWS AuthorAuthors and approved SWS contributors will read and export their own linked papers after identity matching by SWS profile, email and SGEM GlobalID.
For librarian assistance: [email protected]
Purchase Instant Access
- Article can be downloaded after successful payment.
- Article may be used according to SWS library access terms.
- Article cannot be redistributed.
